filename: tfs 150c1.doc version 1.4 30.07.2004 vi telefilter filter specification tfs 150c1 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m measurement condition ambient temperature: 23 c input pow er level: 0 dbm terminating impedance: * input: 3800 ? || -0.7 pf output: 3800 ? || -0.7 pf ch aracteristics remark: reference lev e l for the relativ e attenuation a rel of the tfs 150c1 is the mini mum in the usable signal bandw idth. the max i mum attenuation a max in the usable signal bandw idth is defi ned as the insertion loss a e . the reference frequency f c is the arithmetic m ean v a lue of the upper ( f 6db+ ) and low e r ( f 6db- ) frequencies at the 6 db filt er attenuation lev e l relativ e to the insertion loss a e . the nominal frequency f n is fix ed at 150,4 mhz w i thout tolerance. the usable singnal bandw idth has to be guarant eed also if the centre frequency f c is shifted due to the temper ature coefficient of frequency tc f in the operating temperature range and due to a produc tion tolerance for the centre frequency f c d a t a ty p. v a lue tolerance / limit insertion loss a e 2,8 db max. 5 db (reference level) nominal frequency f n - 150,4 mhz centre frequency f c 150,41 mhz - 3 db bandw idth bw 107 khz - usable signal band w i dth - mi n. f n 10 khz relativ e attenuation : a rel f 6db- - 75 khz ... f 6db- - 50 khz - min. 15 db f 6db+ + 50 khz ... f 6db+ + 75 khz - min. 15 db f 6db- - 125 khz ... f 6db- - 75 khz - min. 20 db f 6db+ + 75 khz ... f 6db+ + 125 khz - min. 20 db f 6db- - 250 khz ... f 6db- - 125 khz - min. 35 db f 6db+ + 125 khz ... f 6db+ + 250 khz - min. 35 db f 6db- - 500 khz ... f 6db- - 250 khz - min. 50 db f 6db+ + 250 khz ... f 6db+ + 330 khz - min. 50 db f 6db+ + 330 khz ... f 6db+ + 397 khz - min. 40 db f 6db+ + 397 khz ... f 6db+ + 500 khz - min. 50 db f 6db- - 500 khz ... f 6db- - 10 mhz - min. 55 db f 6db+ + 500 khz ... f 6db+ + 10 mhz min. 55 db operating temperature range - - 20 c ... + 70 c storage temperature range - - 30 c ... + 85 c temperature coefficient of frequency tc f **) ca. ? 0,036 ppm/k2 - frequency inv e rsion temperature t 0 25 c - *) the terminating impedances depend on paras itics and q-v a lues of matching element s and the board used, and are to be understo od as reference v a lues only . should there be additional questions do not hesitate to ask for an applicati on note or contact our design team. **) ? f(h z ) = t c f (ppm/ k2 ) x (t-t 0 )2 x f to (mhz) generated: checked / approv ed: vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 150c1.doc version 1.4 30.07.2004 vi telefilter filter specification tfs 150c1 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m f ilter ch aracteristic cons truc tion a nd pin c onne c t ion 149. 9 15 0 1 50. 1 150. 2 150 . 3 15 0. 4 150. 5 150. 6 15 0. 7 150. 8 150. 9 -100 -90 -80 -70 -60 -50 -40 -30 -20 -10 0 f r equen c y i n m h z m a g n i t u d e i n d b 150. 34 150. 3 6 150. 3 8 15 0. 4 15 0. 42 1 50. 44 1 50. 46 -8 -7. 5 -7 -6. 5 -6 -5. 5 -5 -4. 5 -4 -3. 5 -3 f r equen c y i n m h z m a g n i t u d e i n d b (all dimensions in mm) 50 ? t est circu i t 1 : 50 ? t est circu i t 2: c 1 l 2 l 1 5 0 ? 5 0 ? l 4 c 2 l 3 c 2 c 1 c 1 50 ? 50 ? c 4 c 2 c 3 8 6 2 1 date code: y ear + w eek s 2004 t 2005 u 2006 ... 1 input 2 input 3 ground 4 ground 5 ground 6 output 7 output 8 ground 9 ground 10 ground TFS150C1 s31 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 150c1.doc version 1.4 30.07.2004 vi telefilter filter specification tfs 150c1 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m stability characteristics after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; packin g tape & reel: iec 286 ? 3, w i th exeption of value for n and minimum bending radius; tape ty pe ii, embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters peer reel: 3000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao p u ll o f f d i r e c t io n pin m a rk er ty p da te c o d e ko t tape (al l di mensi ons i n mm) w : 16,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,10 f : 7,50 0,10 g(min) : 0,60 p2 : 2,00 0,1 p1 : 12,00 0,1 d1(min) : 1,50 +0,1/-0 a o : 7,60 0,10 bo : 9,60 0,10 ct : 13,5 a c n w 1 w 2 r eel (all d i men s io n s in mm) a : 330 w 1 : 16,4 w 2 (max ) : 22,4 n(min) : 50 c : 13,0 the minimum bending radius is 45 mm. vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 150c1.doc version 1.4 30.07.2004 vi telefilter filter specification tfs 150c1 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile name: pre-heating periods main-heat ing periods peak temperature temperature: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 table for temperature vs. time during the air reflow process tolerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 150c1.doc version 1.4 30.07.2004 vi telefilter filter specification tfs 150c1 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m history version reason of changes name date 1.1 generation of specification according to cu stomer requirements. dunzow w. 11.10.2001. 1.2 change defenition of insertion loss. dr. wall 14.11.2001 change remark according to temper ature dependence and production tolerance. remove attenuation requirement at f n 910 khz. add selection at f 6db - -500 khz. define frequency range w e re ultimate rejection of 55 db is measured. 1.3 add formula for calculation of tem perature dependence of frequency . dr. wall 24.04.2002 change frequency inversion temperature to 25 c. 1.4 correct termination impedances. dr. wall 27.07.2004 correct tape and reel. add filter characteristic. vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
|
